Romans lend me your ears,again

Need advice on which oil to use or which tyre best suits you? Share your topic and get help here.
Post Reply
User avatar
fabiostar
Posts: 7635
Joined: Sat Jun 01, 2013 3:53 pm
Location: sunny belfast

Re: Romans lend me your ears,again

Post by fabiostar »

cheers folks, il just step away from it for a while.. im hoping the rich running is because of the timing being wrong as iv had the carbs of and checked them a few times and cant see anything amiss with them or any of the pipes...
the older i get,the faster i was :lol:
Top
User avatar
fabiostar
Posts: 7635
Joined: Sat Jun 01, 2013 3:53 pm
Location: sunny belfast

Re: Romans lend me your ears,again

Post by fabiostar »

ok started from scratch ,front cyl set to. ft, rear cyl spun round the 3/4 it needed. cams wre all over the place. no idea what stroke they were on but pulled them out, fitted them as per the mcct thread. checked anything else i could like carbs and wiring and fired it up. first hit of the button and ticking over way better than it was, even sounded better so out for a we scoot.

no lumpy running just felt like a different bike :biggrin ... right up to 5.5k and the humpy blue b8stard is still the same.. refuses to rev through it and i held the fuker to see if it would.... :think: :think: :think: ..
Last edited by fabiostar on Fri Mar 31, 2017 2:02 pm, edited 1 time in total.
the older i get,the faster i was :lol:
Top
User avatar
MacV2
Posts: 17543
Joined: Sun Jan 21, 2007 12:07 pm
Location: Grain

Re: Romans lend me your ears,again

Post by MacV2 »

fabiostar wrote:ok started from scratch ,front cyl set to. ft, rear cyl spun round the 1 turn and a quarter needed. cams wre all over the place. no idea what stroke they were on but pulled them out, fitted them as per the mcct thread. checked anything else i could like carbs and wiring and fired it up. first hit of the button and ticking over way better than it was, even sounded better so out for a we scoot.

no lumpy running just felt like a different bike :biggrin ... right up to 5.5k and the humpy blue b8stard is still the same.. refuses to rev through it and i held the fuker to see if it would.... :think: :think: :think: ..
Simple thing to check...The petcock diaphragm for splits...then the carb diaphragm for splits or pin holes...


Also just a thought when you took it out for a run 1st time & run out of fule you may have pulled some crap out of the tank & into the carbs...be worth checking your fuel filter in the tank they can be a git to get out tho...
Making up since 2007, sometimes it's true...Honest...
Top
User avatar
fabiostar
Posts: 7635
Joined: Sat Jun 01, 2013 3:53 pm
Location: sunny belfast

Re: Romans lend me your ears,again

Post by fabiostar »

im gona check the diaphram in the tank and change ecu from the red bike and rule those out, frustrating as im so close..


failing that im gona take mind altering drugs and slump in a corner crying.. :Beer Popcorn:
the older i get,the faster i was :lol:
Top
User avatar
AMCQ46
Posts: 16590
Joined: Mon May 11, 2009 4:54 pm
Location: Worcestershire / Warwickshire border

Re: Romans lend me your ears,again

Post by AMCQ46 »

fabiostar wrote:ok started from scratch ,front cyl set to. ft, rear cyl spun round the 1 turn and a quarter needed. cams wre all over the place. no idea what stroke they were on but pulled them out, fitted them as per the mcct thread. checked anything else i could like carbs and wiring and fired it up. first hit of the button and ticking over way better than it was, even sounded better so out for a we scoot.

no lumpy running just felt like a different bike :biggrin ... right up to 5.5k and the humpy blue b8stard is still the same.. refuses to rev through it and i held the fuker to see if it would.... :think: :think: :think: ..
Based on the line highlighted above, he has put the timing to 180 deg out!!!!! if you start at the front cyl, you gou ACW by 3/4 turn to get the correct RT mark........... But I spoke to Rob already and he is sure he only did 3/4 turn... its just he cant type!!!

I think we need to put him on suicide watch 8O
AMcQ
Top
User avatar
fabiostar
Posts: 7635
Joined: Sat Jun 01, 2013 3:53 pm
Location: sunny belfast

Re: Romans lend me your ears,again

Post by fabiostar »

YYYYEEEEEEHHHHHHHHHHOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOO got it sorted...

for sale, one ECU.... :confused . changed the ECU from the yellow bike and away it went... thank the lord himself iv won. iv also learnt more about bikes in the last few days than the last 10 years.......

major beer time :beer: :beer: :beer: :beer: :beer:
the older i get,the faster i was :lol:
Top
User avatar
AMCQ46
Posts: 16590
Joined: Mon May 11, 2009 4:54 pm
Location: Worcestershire / Warwickshire border

Re: Romans lend me your ears,again

Post by AMCQ46 »

:clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap: :clap:
AMcQ
Top
User avatar
fabiostar
Posts: 7635
Joined: Sat Jun 01, 2013 3:53 pm
Location: sunny belfast

Re: Romans lend me your ears,again

Post by fabiostar »

lol cheers Al.... one problem masking the other but all sorted.....


oh i feeeeeeeeeeeeel gooooooooooooood today..
the older i get,the faster i was :lol:
Top
hallie
Posts: 292
Joined: Sat Mar 14, 2015 10:11 am
Location: Cork Ireland

Re: Romans lend me your ears,again

Post by hallie »

Good stuff Rob........ Now you know how 4t works :D :D :D :D :D :D
TIP; Never take a sleeping pill and laxative on the same night
http://morrisonbhp.net/
Top
User avatar
alanfjones1411
Posts: 2800
Joined: Thu May 21, 2015 3:33 pm
Location: watford

Re: Romans lend me your ears,again

Post by alanfjones1411 »

Good news Rob. Go and have a beer or two mow :thumbup: :thumbup:
SO WHEN DOES THIS OLD ENOUGH TO KNOW BETTER KICK IN
Top
User avatar
VTRDark
Posts: 20010
Joined: Sun Mar 18, 2012 9:24 pm

Re: Romans lend me your ears,again

Post by VTRDark »

Have you been for a good run and does she rev past 5.5k. How's your fuelling?
==============================Enter the Darkside
Top
User avatar
lloydie
Posts: 20923
Joined: Mon Jan 17, 2011 11:16 pm
Location: In the garage somewhere in Coventry

Re: Romans lend me your ears,again

Post by lloydie »

Someone is going to have a good weekend now
Top
User avatar
fabiostar
Posts: 7635
Joined: Sat Jun 01, 2013 3:53 pm
Location: sunny belfast

Re: Romans lend me your ears,again

Post by fabiostar »

lloydie wrote:Someone is going to have a good weekend now ImageImageImageImageImageImageImageImageImageImage
a bloody great weekend..

ay its revving the very best. still running rich low down but il sort that easy enough but not now, for now i just want to gear up on sunday and bring it out for a chilled out thrash..... :thumbup:
the older i get,the faster i was :lol:
Top
User avatar
sirch345
Site Admin
Posts: 21856
Joined: Mon Aug 25, 2003 10:35 pm
Location: The West Country.

Re: Romans lend me your ears,again

Post by sirch345 »

fabiostar wrote:YYYYEEEEEEHHHHHHHHHHOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOO got it sorted...

for sale, one ECU.... :confused . changed the ECU from the yellow bike and away it went... thank the lord himself iv won. iv also learnt more about bikes in the last few days than the last 10 years.......

major beer time :beer: :beer: :beer: :beer: :beer:
Really good news :clap: As I said in your other thread, I'm glad you got to the bottom of the problem :thumbup: :beer:

Chris.
Top
User avatar
fabiostar
Posts: 7635
Joined: Sat Jun 01, 2013 3:53 pm
Location: sunny belfast

Re: Romans lend me your ears,again

Post by fabiostar »

sirch345 wrote:
fabiostar wrote:YYYYEEEEEEHHHHHHHHHHOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOO got it sorted...

for sale, one ECU.... :confused . changed the ECU from the yellow bike and away it went... thank the lord himself iv won. iv also learnt more about bikes in the last few days than the last 10 years.......

major beer time :beer: :beer: :beer: :beer: :beer:
Really good news :clap: As I said in your other thread, I'm glad you got to the bottom of the problem :thumbup: :beer:

Chris.
i lokked at that timing so many times i got myself in a tiz esp when it was fixed it still ran crap so ended up questioning myself had i really fixed it, but having the ecu play up at the same time was masking anything i was doing with the cam timing.. :thumbup: :thumbup: :thumbup:


great advice on here so beers on me lads..
the older i get,the faster i was :lol:
Top
Post Reply

Return to “Workshop”